The Ohlins STX 46 Street rear shock for the Suzuki SV 650 and SV 650X is built to deliver controlled damping and clear feedback for real-world road riding. It’s designed to improve chassis stability and tyre contact over changing surfaces without making the bike feel harsh. The STX architecture is aimed at consistent performance across longer street sessions.

Ohlins | Made to race, perfected to ride

Ohlins suspension is developed with a focus on predictable control and repeatable damping behaviour. On the SV 650 platform, this rear unit is intended to support more confident cornering and braking feel through improved rear-end control.

Shock design & features

This is a gas-pressurised, oil/gas separated rear shock (not an emulsion design), helping the damping remain consistent as the shock works through heat and repeated movement. The STX 46 Street layout is intended to provide stable damping characteristics and reliable feel across typical street conditions.

Tuning controls

This shock provides rebound damping adjustment so you can fine-tune how quickly the rear returns after compression. It also includes a spring preload adjustment to set ride height balance and suit load, rider preference, and tyre choice.

Base setup (factory preset)

The shock is supplied with an Ohlins baseline tune intended to suit the standard motorcycle and general street use. From there, small changes to preload and rebound can be used to tailor comfort, grip and support to your riding conditions.

Before you install

  • Confirm model and year compatibility for Suzuki SV 650 and SV 650X before installation.
  • After fitting, set sag via spring preload and then refine rebound to match your tyre, pace and road surface.
  • If your bike carries regular luggage or a passenger, expect to revisit preload settings.

Serviceability/lifecycle

This Ohlins rear unit is fully serviceable. Periodic oil and wear-part servicing helps maintain damping consistency and extends component life, especially if the bike sees frequent spirited riding or wet/dirty conditions.

Öhlins Motorcycle Suspension Warranty

New Öhlins motorcycle shock absorbers, front forks and cartridge kits supplied by Teknik Motorsport are covered by the applicable Öhlins manufacturer’s warranty against defects in materials and workmanship.

Teknik Motorsport is an authorised Öhlins Service Centre and administers warranty claims in accordance with the Öhlins warranty conditions. The service intervals below form part of the maintenance requirements for Öhlins products supplied and supported by Teknik Motorsport.

This warranty is in addition to the consumer guarantees that apply under the Australian Consumer Law.

  • Registered motorcycles — non-competition road use Five years, subject to correct application, installation, setup and servicing every: 20,000 km or two years, whichever occurs first.
  • Registered motorcycles — adventure and light off-road use Five years, subject to correct application, spring rate, setup and servicing every: 10,000 km or annually, whichever occurs first.
  • Unregistered or competition motorcycles Two years for eligible Öhlins MX and Enduro products, subject to inspection every ten hours and servicing every: 30 operating hours or annually, whichever occurs first.

Compliance with the applicable service interval is a condition of the Öhlins manufacturer’s warranty. Evidence of servicing may be required when a warranty claim is assessed.

A seal leak, loss of damping performance or internal wear arising after the prescribed service interval has been exceeded will be treated as a service or maintenance issue rather than a manufacturing defect.

Warranty repairs

Öhlins suspension products are designed to be serviced and repaired. Where a warranty claim is approved, the normal remedy is repair of the customer’s original suspension unit using genuine Öhlins replacement parts.

Replacement of a complete shock absorber, fork or cartridge kit is not automatic and would normally occur only where the product has suffered a manufacturing failure that cannot reasonably be repaired. This is at Ohlins discretion. 

Öhlins spare parts and service kits

Öhlins spare parts, seals, bushes, service kits, springs, fluids and individual components are covered only against defects present when supplied.

No fixed age-based warranty applies to wear items, service parts or consumable components. Wear, deterioration, contamination, incorrect installation and damage caused by another component are not manufacturing defects.

Öhlins gives the customer a meaningful five-year warranty on products (Units), provided the suspension is maintained as suspension should be maintained. Teknik supports that warranty locally, can inspect the product properly, and can repair it with genuine parts rather than discarding it.

SKU SU423
Model # S46DR1
Barcode # SU423
Brand Ohlins
Shipping Weight 5.0000kg
Shipping Size 0.300 x 0.300 x 0.500m
Type Units
See our Shipping Information See our Frequently Asked Questions
Position (Front or Rear) Rear Mono
Shock Length Eye to Eye (mm) 317.0
Spring Rate Standard 85.0 N/mm
Type Code S46DR1
Stroke Metal to Metal (mm) 63.0
Product Family STX 46 Street
Fitted Spring 01092-26
Spring Colour Yellow
Rec. Ohlins Oil 01309-

More From This Category